View Full Version: Convoy and 400 Help

Convoy and 400 Help topics

• Brakes
• ldv convoy td starting problem
• newbie needing help with front axle problem
• UPDATE ON 2.5DI STARTER/IMMOBILISER FAULT
• DMF Clutch??
• 2001 2.5 DI CONVOY STARTER/IMMOBILISER FAULT?.
• Minibus rear speakers..
• getting a horrible clonk
• UPDATE ON 2.5DI STARTER/IMMOBILISER FAULT
• gearbox removal
• CONVOY STARTER SOLENOID
• Bleeding the fuel on a convoy 400
• Heater Console Backlight Bulbs
• Headlights
• MOT soon still have Excessive brake travel (1 2 3 4 5 6)
• New CD/Radio fitting
• hi-level 3rd brake light-for hi-loader convoy
• ldv 400 width????
• interior lights
• Duratorq cylinder block drain plug
• Hazard warning lights
• New part Numbers (1 2 3)
• Motor model identification
• Clutch Cable Snapped- in Spain!!
• LDV CONVOY FORD TRANS ClUTCH CABLE ADJUSTMENT
• Rear Number plate panel
• Novice owner needing some advice
• Haynes Manuel (convoy 400 2000)
• Mushroom Panel Buttons
• epic pump
• Clutch components
• rear brakes
• Brake Drum Assembly for 400 series N reg
• oil seal part no-convoy front hub
• near side mirror
• flame start
• convoy dash
• Wiring Towbar
• ldv convoy 400 high roof
• 2.4 Engine to Gearbox torque wrench settings.
• Convoy 400 Oil Leak
• Two questions please
• Sliding door hinge
• convoy luton payload
• weller wheels
• rear shoes replacement
• Torque Wrench Settings
• windscreen rubber
• oil in water
• having a tacho ?
• Chilly Battery Help Please
• swaying van
• Intermittent noise from rear axle
• Roughly how much for
• bone shaker
• insurance rip offs
• gutless new engine!!!
• 2.4 Fuel filter swap..
• leaking expansion tanks
• heres a thing
• buying advice needed
• 400 series window glass??
• new van and insulation
• LDV CONVOY 2003 starting problems
• Convoy door locking- interior..
• miss fire problems
• Just bought a convoy....LSD?
• Very Worried
• Free hanging wash bottle?
• Removing the propshaft on a 400
• gunged up inlet manifold-banana engine
• Couple Of LDV SWB Minibus Questions (T Reg)?
• Duratorq 2.4 75ps - fuel filter causing problems..?
• Transporting a LWB Hi Top LDV
• lots of questions for a pending 400 conversion
• Convoy brake kit
• 2.4 Duratorq (75ps) holding back..?
• Excessive brake pedal travel
• Headrest Removal ?
• And so it begins. (1 2)
• 400 and convoy engines.
• Who needs gears!
• Dreaded Rust
• Starting/Charging Issue! (1 2)
• convoy rear lock
• some advice on this please....
• New to LDV, new to vans - a bit worried
• WIPERS
• Oh dear MOT time
• changing fuel filter
• Moved Airfilter box.
• ET70 diagram. Anyone help?
• Brake then rev on its own, gear box Q as well
• Tyre Valves
• swb high top convoy van internal size
• convoy rear doors.
• Best tyres for a twin wheeler 400? (1 2)
• not over heating just getting damn hot
• 2.5 N/A banana -vs- 2.4TD Duratorque
• Clutch Gearbox problem?
• Water pump leak?
• Odd Radio Connector...
• left headlamp stays on full beam
• Nice easy job Brake cylinder.
• Convoy 400 Brakes Again
• Oh bugger, this may get expensive.. wheel, brakes, steering?
• Clutch Cable - help confused!
• london transport
• 75ps or 90ps ford engine
• 400 V8 - restrictors??? (1 2)
• steering probs
• wheel bearings
• Prop Shaft!
• air suspension
• ldv convoy 400 2.o litre petrol/gaz 3.5t
• Converting to petrol
• Replacement bits for a 1991 400
• Alternative Drivers seat.
• Horn Not Working...help!
• High Idle speed
• types of convoy
• pug engine & box weight, need to no for shipping
• 1995 Clutch
• Gearbox
• water pump
• diff
• keys
• Keys locking other ldv's
• Engine swap
• TURBO TO NON TURBO CONVERSION 2.5 PEUGEOT ENGINE
• TOP END RATTLE ( BUT I DONT THINK TAPPETS ) ANY SUGESTIONS
• No Highbeam well some.
• Dimensions
• engine management light
• ECU Wanted
• Poorly Lucy!!
• Rear Wheel Cylinder
• Instrument cluster
• What gearbox?
• Just bought a lovely van with a few issues...
• Compressor relay supplier
• adjuster screw (steering)
• leak does not start
• convoy steering?
• how easy is to change injectors
• Kingpin location
• Dual Mass Fly Wheel Conversion
• 400 Convoy wont start
• viscous coupling
• tyre woes
• LDV 400 GEARBOX OIL, 1996 2.5D PEUGEOT ENGINE???
• Oil filter removal and refit
• FLUID LEVELS
• Dual line calipers on single line system???
• Whining power steering
• Replacement Roof!!
• cam belt tensioner 2.5 di engine
• Convoy front axle advice
• horn location
• Second hand ECU
• Engine Losing Power
• Fuse box
• Boosting Duratorq's power with Transit turbo and parts?
• 1995 LDV 400 clutch (1 2)
• 400 Gearbox p5-100 selector problem
• exhaust advice needed (1 2)
• help needed again please
• convoy 2.5DI
• cal. pistons
• caliper
• convoy hand brake
• the other site
• 2002 2.4 Duratorque engine stopping
• Need some juice!
• broken ignition barrel help!!!
• my ldv 400 convoy 2.o ltr pet/lpg
• odo / trip counter fault
• Thanks Pete(farrell360)..!
• Changing the brake pedal switch
• headlamp adjusters ... for a 400
• 400 suspension air tank
• 400 pug radiator
• Fuel Gauge
• Spare Wheel on 400 hiTop
• 2003 LDV convoy tipper immobiliser
• Paint (again!)
• Gearbox bush(?)
• length
• Tyres
• MOT failure on king pins and brakes
• Heater fan..
• specifications needed for Daf City Special 400
• Remote locking...
• MAP SENSOR 2.4 DURATORQ ?????? HELP HELP
• 75ps or 90ps 2.4td
• SAILSBURY AXLE SPEC S
• interior plastic panel fixings
• water leaking below fan
• steering box
• tyre valve stem
• Durotorq no go
• Removing seats, registering and insurance.
• AIR SUSPENSION KIT
• legally putting seats in vans.
• Air suspension, how to make it work
• 51 plate convoy in need of lots of work advice needed
• bleeding convoy! 2.5di
• Door handle problem...
• Heater plug light
• Convoy heater / Control Valve clips
• chassis cab weights
• intermittant smokey rough idle
• help clutch cable has snapped
• Excessive Oil Consumption?
• cheap minibus sales
• Convoy,wet socks
• Radio Fuses and Problems
• Rear heater
• pad fitting kits
• rear wheels locking up (1 2 3)
• I need help!
• Ceramic heater
• Convoy 400 LWB (1 2)
• Keys
• 400 Convoy comfort level upgrade...
• Help scrap my van please!
• help neeeded does not start (1 2)
• Alternator belt LDV 400
• LDV 400 Luton Ignition Barrel
• Fuel sender
• Paint.. where do I get some?
• wide angle wing mirror upgrade for 2001 Convoy???
• Convoy Door Speakers.
• pilot diff in a convoy
• 2000 W 400 Convoy door locks..
• 400 Convoy axle oil replacment.
• 2000X convoy 2.5DI N/A fuel prob
• Oil and filter on pug 2,5TD (1 2)
• POSSIBLE DESEL ENGINE FAULTS
• Road camber..
• Please Help!!
• Duratorq help/info
• convoy what engine?
• fuel filter changing
• Steering box MOT failure
• Steering next steps??
• Rear axle
• Front Seat
• Smoking when cold
• Alternator help
• suspension won't rise. (1 2)
• LDV 400 Differentials
• Air direct to air bags?
• Rear wheel bearing removal / replacing, advise required. (1 2)
• BLACK SMOKE ON ACCELERATION
• Pinion Tail Bearing
• LEZ TFL Theiving Beggars
• Fitting new side windows...
• Glow plugs and relay pug 2.5 td
• Wheel nuts totally stuck!
• Wet carpets (.. yes, that old chestnut again!) (1 2)
• recovery truck nearly finished but need a few bits
• Ldv Convoy 400 EGR MOD?
• Horizontal shock absorber replacement/Propshaft vibration
• convoy model question
• Misfire III - anyone got The Samaritans number..?
• door locks , there canibalism and remaking
• hi-top removal and refitting
• 1990 models
• Manual/fuses? (1 2)
• hub seals
• yet another gutter leak question :)
• Starting problems :-(((
• Still leaking oil
• has anyone ever.......................
• convoy fuel pump swap?
• Warning light LDV convoy orange spanner help
• o/s front brake grabbing/locking up!!!!!!!!!!!!!!!!!!!!!!!
• considering changing timing belt
• convoy immobiliser
• best place to get convoy spares
• List of newbie questions (1 2)
• tipper hydraulic problems
• using two batteries
• banana engine??
• fuel prima 400 convoy d lwb
• no brakes!!!
• acetone
• Lots of help- but still baffled..(?)
• Smoke on start up - then ok??
• wheel bearings?
• 2.5 N/A 'nana Fuel Filter install- a newbie asks..
• ldv front axle ?????????????
• LDV 400 Chassis Cab Kerb WEIGHT??
• Dash lights
• Misfire- spoke too soon..!
• please help im desperate
• A big 'Thank you'...
• Help for 400 ldv with hi-top
• Convoy/400 top speed?
• what size wheels ? 2.8t Convoy
• convoy calipers
• LSD oil additive?
• Duratorq oil filter
• convoy missfire (1 2)
• Dismantling door sides
• convoy caliper pistons?
• Water leaks.. again(!)
• EGR mod
• Water leak
• should brake fluid get hot?
• Convoy windscreen rubber ?
• brake pipe size help
• Charging problems
• convoy n/s wing
• SIX SPEED GEARBOX CONVERSION
• turbo boost sensor??? 2.4 dura engine
• clutch not disengaging.
• Advanced ignition problem?
• BRAKE BLEEDING
• Convoy Steering box leak!!!
• new engine for ldv 400
• E reg 350 engine swap
• Convoy hight top paint fade
• is it possible UPDATE (1 2)
• 2.5di Engine Serial Number Location
• Rocker Cover Removal
• ABS Front discs.. Aargh!
• new member needs help.
• ldv convoy fuel filter part no
• aaaghh help
• Workshop Manual
• Polybush Kits
• first time owner ?
• Help Engine management system light - limp home mode (1 2)
• Flat spot when accelerating
• 400 Brake problems
• Flat spot
• 400 convoy steering box
• is it possible 2
• internal Heater/fan Problem
• rhino roofbars dont fit right!!!(they do now !! with pics)
• re ldv convoy 2.5 transit engine, starter motor
• Broken Diesel pump
• Door swap.
• the wonders of the modern age
• highroof roofbars?
• injector pump timing??
• electrics, wiring aaah!!! PLease help
• convoy 400 01 brakes
• What parts are best
• ldv 400 front wheel bearings
• Rear Axle Noise and Clutch Noise
• peugoet turbo 400 on veg oil ?
• 400 rear brake adjusters
• battery drain
• convoy 400
• more 400 brake problems
• wheels
• I got the rot, can I join the club now?
• Key Jammed!
• New Owner :)
• ldv 400 convoy immobiliser?
• EGR mod
• Speedo
• Minibus Side Mouldings
• Vehicle shake
• Simple Consumables and where to buy?
• Type of grease for king pins
• Convoy Suspension
• abs brake discs
• poor 400 convoy repaire costs and time
• Leaks into cabin is rusting my van :(
• wheel wobbles
• reversing light switch??????????
• Drivers door
• water pump :(
• How Hard?
• Garage recommendations Birmingham
• P5-100 Gear Box Stuck in 3rd
• Chain or belt?
• Convoy wohoo but...
• Ford gearbox oil
• convoy 2.5td eratic
• engine oil leak
• NOW FOUND (STOLEN VAN)
• convoy air bag suspension fault
• Cruise control?
• convoy rear brake auto adjuster
• Ldv convoy power loss
• Convoy 2.5Di immobilser by-pass
• Oil change & greaseing king pins
• Brake shoes and springs - advice needed...
• starting problems ... maybe starter motor ?
• ldv 400 convoy 2.5 td 99 cuting out when warm
• Removing rear light clsuter...
• Propshaft Center Bearing
• Rear Leaf Springs (1 2)
• ldv convoy towbar fitting?????????????
• conversion possible?
• LDV Helpdesk Phone Number
• Rear axle ratios
• Engine Light Keeps Coming On
• New VED rates ???
• Rebuild! (1 2 3 4)
• Doors and Seals
• LDV 400 - brake problems.
• Strange injector failure
• What have I done!?!?!!!?!
• Steering problem
• the problem with automatic LDVs.....
• 2001 Convoy 2.5 Di Prop bolt.
• bio-fuel
• major gearbox
• owner's manual and injection pump
• '98 Convoy power problem
• Alternator and relay query for motorhome, also solenoid quer
• electric fan cut in temp
• Front Track
• Convoy 2.5Di ....Touch of black smoke ?
• 04 LDV Convoy
• location of auto gearbox starter inhibitor relay V8
• Mot Failure :(
• locking brakes
• is my fuel pump dying
• livery suggestions welcome
• help brakes (1 2 3 4)
• wheel rim compatability
• Reversing ligh switch.
• 400 rear brake assembly Steady pins
• Total brake fluid change
• LPG not working
• steering play (1 2)
• HELP: Identify this convoy Filter assy pls
• Throttle cable
• Oil Filters
• Convoy 2.5 Di Timing pin dimensions.
• reverse beeper and horn has gone.
• AIR SUSPENSION SYSTEM / wiring DIAGRAM
• tow bar (1 2)
• exhaust
• PTO for freight rover or Leyland DAF
• lucas oil power steering stop leak (1 2)
• SHE FAILED!!!
• Instrument panel
• windscreen wiper stalk
• back axle help
• leaky windscreen
• heater control valve
• Heater in Fuel feed line
• Orange Dash Light? (1 2)
• Rear axle ratios?
• vacum pump
• bodywork prep
• Turbo Problems? (1 2)
• Starter problems! (1 2)
• Uprating headlights (1 2)
• rover v8 in convoy (1 2)
• Rear Axle oil leak (1 2)
• anyone know the mpg of a swb 13 seater minibus convoy
• Engine Manageent system warning light... (1 2)
• van playing up
• speedo
• Oil Additives
• Reversing Cameras
• engine prob
• diesel leak
• LDV Convoy Rear Shoes
• Internal rear view mirror
• wind screen
• insurance? (1 2)
• Rear roller shutter
• fuel injectors
• heater (1 2)
• speddo
• Headlamps
• Electrical question... what's this for?..
• flipping bodgers! more wiring problems!
• seats
• Battery fitment
• TURBO DIESEL intercooler position (1 2)
• LDV worshop manual
• PEUGEOT 2.5 TURBO NON TURBO ENGINE?????????
• rear brake knocking
• veg oil
• CONVOY SIDE LOADING DOOR
• gear ratios
• So what is this 'Kingpin' business?
• engine heating time
• STILL got that immobilisor problem,arrrrrrrrrrh!!!!!!!!
• injector pumps
• My band (and their van) needs some advice...
• rear spring rates
• new job, new photoseries!
• Rattling Noise
• Ply lining and van racking
• Coolant Change - Cylinder Block Drain Plug
• Tyres
• Door hinges, doh!!!
• Drivers seat cushion
• GEARBOX OIL AND LEVEL'S
• Convoy Conversion
• ldv convoy transit engine
• Drip
• Reverse lights and wipers (1 2)
• Fuses..
• Pulling to the left???
• SEATS FOR SALE
• DIESEL FILTERS????
• Frickin' Fuel all over the gaff! (1 2)
• towing plug
• Water in Fuel light
• fuel gauge
• Drivers seat
• starts purrrrrfect drive 2 or 22 turn off wont start
• All bent out of shape!!NOT FOR THE FAINT HARTED!! (1 2)